Dispersant 5040-Paint color paste Ink Additives_AILPSS“澳卢实业发展(上海)有限公司

企业概况 / Company Profile

Dispersant 5040

Efficient pigment dispersant

RF-5040

概述  Overview

RF- RF- 5040是一种高效、低成本颜(填)料分散剂，对水性涂料用颜(填)料具有极佳的分散稳定作用。 5040 is an efficient, cost-Yan (fill) material dispersant, the waterborne coating Yen (fill) material has excellent dispersion stability.

典型特性 Typical characteristics 

外观：黄色透明粘稠液体 Appearance: yellow transparent viscous liquid

组成成份：聚羧酸钠 Composition: Sodium polycarboxylate

固含量：40% ±2% Solid content: 40% ± 2%

溶解度：在水中易溶解 Solubility: Easy dissolve in water

优点  Advantages

(1) 分散效率高：RF- (1) dispersion and high efficiency: RF- 5040分散剂用量少，在分散过程中无需辅助分散剂。 5040 with less dispersant in the dispersion process without secondary dispersant. 对多种颜料所作的分散剂用量试验的结果表明，RF- By a variety of pigment dispersant test results show that, RF- 5040的最佳用量低，研磨的粘度也很低。 5040 The optimum dosage is low, the viscosity is very low ground. 分散粘度曲线为平L型，表明用量过多也不致有不良影响。 Dispersion viscosity curve is flat L-type, indicating that the amount does not cause excessive adverse effects. 因此，当选择适当用量的RF- Therefore, when selecting the appropriate amount of RF- 5040时，即使颜料量有变化，涂料的光学和物理性质仍可保持稳定。 5040, even if there are changes in the amount of pigment, the optical and physical properties of paint can still maintain stability.

(2) 粘度稳定好：RF- (2) good viscosity stability: RF- 5040可使涂料的粘度非常稳定，经过热老化试验(50℃超过一个月)，粘度仍不会变化。 5040 can paint viscosity is very stable, heat aging test (50 ℃ more than a month), the viscosity still does not change.

(3) 优异的保光性：在有光漆和半光漆中应用RF- (3) excellent gloss retention: the bright paint and the application of semi-gloss paint RF- 5040，可以得到优异的初始光泽，经热老化后，保光性好。 5040, can be excellent initial gloss after heat aging, the security light is good.

(4) 完全的展色性：RF- (4) full color development: RF- 5040能够改善调色性。 Can improve the color of 5040. 用色浆调色时，常将该分散剂加到涂料中，改善调色性。 With paste color, often in the dispersing agent added to paint to improve the color of. 经验证明，在调色料中用RF- Experience has shown that compound with the RF-in color 5040作为颜料分散剂，不仅可以不用润湿剂而不致影响调色效果，而且可以提高耐水性和节约成本。 5040 as a pigment dispersant, wetting agent which can not only do not affect the color effect, but also improve the water resistance and cost savings.

(5) 可和活性颜料并用：RF- (5) and activity of the pigment and can be used: RF- 5040可和氧化锌等活性颜料并用。 5040 activity can be, and zinc oxide pigments and use. 例如，在研磨料中以它作为唯一的分散剂，氧化锌含量可允许达到2.0%。 For example, in the abrasive to it as the sole dispersant, zinc oxide content can be allowed to reach 2.0%. 制出的油漆具有平坦的粘度曲线，在50℃下经过一个月的热老化试验之后，粘度稳定(粘度差不超过2 KU)。 System out of the paint with a flat viscosity curve, at 50 ℃ after a month after the thermal aging test, stable viscosity (viscosity difference of not more than 2 KU). 无需加辅助分散剂、润湿剂或非离子型表面活性剂。 No additional secondary dispersant, wetting agent or non-ionic surfactant.

(6) 泡沫少：含有RF- (6) Foam less: containing the RF- 5040的涂料发泡性很低，其原因有三个。 5040 paint foam is very low and there are three reasons. 首先是因为这种分散剂本身具有低泡性。 First, because the dispersant itself has low foaming. 其次由于不需要另加表面活性剂，故减少了产生泡沫的机会。 Second, eliminating the need for additional surface active agent, it reduces the chance of a bubble. 第三个原因是分散效率高，用量少。 The third reason is the spread of high efficiency, with less. 所以，添加RF- So, add the RF- 5040后，涂料在制造和使用过程中都很少起泡沫。 5040, the coating process in the manufacture and use very little lather.

(7) 耐擦洗性佳RF- (7) Good RF-scrub 5040用量少，又很少需要再添加其它润湿剂来改善分散性和调色性，这使干漆膜具有优异的耐水性。 5040 with less, and rarely need to add additional wetting agent to improve dispersion and color of which the dry film has excellent water resistance.

应用  Application

RF- RF- 5040 具有最大的颜料承载力，经济可行，适用于多种颜填料体系，包括有光和平光级金红石钛白粉，天然碳酸钙和瓷土。 5040 with the largest color capacity, economically feasible for a variety of pigment system, including the bright light grade rutile titanium dioxide peaceful, natural calcium carbonate and clay. 在生产铁红、铁黄色浆及钼桔红分散液时， RF- In the production of iron oxide red, iron and molybdenum orange yellow slurry dispersion when, RF- 5040 也很有效。 5040 is also very effective.

RF- RF- 5040 对钛白和填料是主分散剂，不需添加辅助分散剂或润湿剂。 5040 pairs of titanium dioxide and fillers is the main dispersing agent, without adding secondary dispersant or wetting agent. 它和乙二醇及丙二醇的相容性极佳，方便在分散研磨机中使用。 It is ethylene glycol and propylene glycol and excellent compatibility, easy to use in the dispersion mill.

RF- RF- 5040 在很宽的用量范围内均有效，具体用量根据颜料载体和涂料种类有所不同，一般用量范围在0.2 ~ 1.0%(固体/固体)，上限适用于高光及难分散体系，下限适用于平光体系，当添加少量的RF- The amount of 5040 in a wide range are valid, the specific carrier and the amount of pigment coating according to different categories, the general dosage range of 0.2 to 1.0% (solid / solid), ceiling light and difficult for high dispersion, the lower limit for plain system, when a small amount of RF- 5040时，可改善体系的展色性。 5040, can improve the system of color development.

包装  Packaging

50 kg/桶、250 kg/桶、按客户定制包装 50 kg / drum, 250 kg / barrel, according to custom packaging

所有数据，包括配方均是真实的。 All data, including the formula are true. 但是客户必须在自己的试验室或设备上进行试验来确认，本公司不能做出任何承诺。 But the customer must in their own laboratory or test equipment to confirm that the company can not make any promises. 客户必须遵守当地的专利法规。 Customer must comply with local patent laws. 供应商有权对自己的产品进行改进，其规格有任何改动，恕不提前通知。 Suppliers have the right to improve their products, their specifications to change without notice.